Used DPS6 Transmission for Sale

About This Transmission

The Ford DPS6, marketed by Ford as PowerShift and engineered as the 6DCT250, is a 6 speed dry dual-clutch automatic transmission used in the Ford Fiesta, Focus, C-Max, and select Fusion trims from 2010 through 2019. Unlike a traditional torque-converter automatic, the DPS6 uses two dry clutches and a Transmission Control Module to deliver shifts that are quicker than a hydraulic automatic and more fuel-efficient at the same time. Inside the case, two clutch packs alternate engagement as the gearbox swaps between odd and even gear pairs.

This setup gives the DPS6 PowerShift its signature feel: brisk acceleration off the line, manual-like efficiency on the highway, and lower fuel consumption than a comparable conventional automatic. For Fiesta and Focus owners replacing a worn or coded-out unit, a clean used DPS6 is a far better value than rebuilding the original.

Signs You Need a Replacement DPS6

• Shudder or jerkiness during low-speed acceleration, clutch wear or TCM adaptation drift
• Hard or delayed shifts between 1st and 2nd gear, dual mass flywheel or clutch fork wear
• Transmission warning light, TCM faults or stored shift adapt codes
• Loud bearing noise from the bell-housing area, input shaft bearing wear
• Slipping or no engagement in one gear range, clutch pack failure
• Burning smell after stop-and-go driving, dry clutch wear

Known DPS6 Issues We Inspect Before Shipping

• Clutch fork wear and clutch pack thickness, the most common DPS6 failure point
• TCM operation and stored adapt values, critical for smooth performance after install
• Input shaft and bearing condition
• Case integrity and seal surfaces
• Mechatronic unit operation where applicable
• Year-specific TSB updates, documented when present

What Is Included, What Is Not Included

The DPS6 PowerShift transmission was a direct fit in the following vehicles:

Engine pairings: 1.0L EcoBoost I3, 1.6L Duratec, 1.6L EcoBoost I4, 2.0L Duratec I4. Tell us your engine and we confirm the correct DPS6 calibration version before shipping.

Not sure if this fits? Call (240) 301-0095 with your year, model, trim, and engine code. Our team verifies fitment before every order ships, including correct TCM calibration and bolt pattern for your specific Ford application.

Every used DPS6 we ship goes through this process:

• Functional check on bench, both clutch packs verified for engagement
• Internal visual inspection of clutch pack thickness and fork condition
• TCM communication test and stored fault check
• Bell-housing and case integrity check
• Seal and gasket surface inspection
• Year and donor application documented when available

Where mileage from the donor vehicle is known, we share it. Where mileage cannot be confirmed, we disclose it before order. Full inspection documentation is available on request.

Why Buy From Vaz Auto Solutions

• Inspected and operation-verified before shipping
• Clutch pack thickness measured and documented
• TCM operation confirmed clean and ready
• Year and donor application confirmed for every unit
• Free crated freight delivery to all 50 states, no hidden fees
• No core charge, keep your old transmission
• 15 day replacement warranty on internal defects
• Ford-experienced support team on the phone